Toyota
Dodge Durango
 Service Manual
Engine » Service procedures
Valve service

REFACING

NOTE: Valve seats that are worn or burned can be reworked, provided that correct angle and seat width are maintained. Otherwise the cylinder head must be replaced. NOTE: When refacing valves and valve seats, it is important that the correct size valve guide pilot be used for reseating stones. A true and complete surface must be obtained.

(1) Using a suitable dial indicator measure the center of the valve seat Total run out must not exceed 0.051 mm (0.002 in).

(2) Apply a small amount of Prussian blue to the valve seat, insert the valve into the cylinder head, while applying light pressure on the valve rotate the valve. Remove the valve and examine the valve face.

If the blue is transferred below the top edge of the valve face, lower the valve seat using a 15 degree stone. If the blue is transferred to the bottom edge of the valve face, raise the valve seat using a 65 degree stone.

(3) When the seat is properly positioned the width of the intake seat must be 1.75 - 2.36 mm (0.0689 - 0.0928 in.) and the exhaust seat must be 1.71 - 2.32 mm (0.0673 - 0.0911 in.).

(4) Check the valve spring installed height after refacing the valve and seat. The installed height for both intake and exhaust valve springs must not exceed 41.44 mm (1.6315 in.).

(5) The valve seat and valve face must maintain a face angle of 44.5 - 45 degrees angle.

Fig. 10 Valve Assembly Configuration Fig. 10 Valve Assembly Configuration

1 - VALVE LOCKS (3-BEAD)

2 - RETAINER

3 - VALVE STEM OIL SEAL

4 - INTAKE VALVE

5 - EXHAUST VALVE

6 - VALVE SPRING

    More about «Service procedures»:

    Form-in-place gaskets

    Engine oil

    Repair damaged or worn threads

    Cylinder bore-honing

    Hydrostatic lock

    Valve service

    Engine timing-verification

    Timing chain-measuring wear

    Pistons-fitting

    Piston rings-fitting

    Connecting rod bearings-fitting

    Crankshaft main bearings

    Dodge Durango Service Manual / Engine / Service procedures / Valve service

    Dodge Durango Service Manual

    Categories


    © 2017-2024 Copyright www.dodurango.net
    0.0213