Toyota
Dodge Durango
 Service Manual
Fuel System » Fuel injection system » Removal and installation
Throttle position sensor (tps)-3.9/ 5.2/5.9L engines

REMOVAL

The TPS is located on side of throttle body.

(1) Remove air duct at throttle body.

(2) Disconnect TPS electrical connector.

(3) Remove two TPS mounting bolts (Fig. 21).

Fig. 21 TPS Mounting Bolts-3.9/5.2/5.9L Engines Fig. 21 TPS Mounting Bolts-3.9/5.2/5.9L Engines

1 - THROTTLE POSITION SENSOR

2 - MOUNTING SCREWS

(4) Remove TPS from throttle body.

INSTALLATION

The throttle shaft end of the throttle body slides into a socket in the TPS (Fig. 22). The TPS must be installed so that it can be rotated a few degrees. If the sensor will not rotate, install the sensor with the throttle shaft on the other side of the socket tangs.

The TPS will be under slight tension when rotated.

(1) Install the TPS and two retaining bolts.

(2) Tighten bolts to 7 N*m (60 in. lbs.) torque.

(3) Manually operate the throttle control lever by hand to check for any binding of the TPS.

(4) Connect TPS electrical connector to TPS.

(5) Install air duct at throttle body.

    More about «Removal and installation»:

    Automatic shutdown (asd) relay

    Fuel pump relay

    Oxygen sensor heater relays

    Throttle body-3.9/5.2/5.9L engines

    Throttle body-4.7L v-8 engine

    Throttle position sensor (tps)-3.9/ 5.2/5.9L engines

    Throttle position sensor (tps)-4.7L v-8 engine

    Idle air control (iac) motor-3.9/5.2/ 5.9L engines

    Idle air control (iac) motor-4.7L v-8 engine

    Manifold absolute pressure (map) sensor-3.9/5.2/5.9L engines

    Manifold absolute pressure (map) sensor-4.7L v-8 engine

    Powertrain control module (pcm)

    Oxygen sensor

    Air cleaner element (filter)

    Engine coolant temperature sensor-3.9/5.2/5.9L engines

    Engine coolant temperature sensor-4.7L v-8 engine

    Intake manifold air temperature sensor-3.9/5.2/5.9L engines

    Intake manifold air temperature sensor-4.7L v-8 engine

    Power steering pressure switch

    Dodge Durango Service Manual / Fuel System / Fuel injection system / Removal and installation / Throttle position sensor (tps)-3.9/ 5.2/5.9L engines

    Dodge Durango Service Manual

    Categories


    © 2017-2019 Copyright www.dodurango.net
    0.0024